1、 Product description

導軌式升降貨梯是一種非剪叉式升降機，整體采用高強度錳鋼矩管制造，配以鋼絲繩調節平衡，各樓層和升降臺面均可設置操作按鈕，實現多點控制，上下樓層互動連鎖達到使用。液壓頂升系統采用旁置油缸（兩側油缸）設計，升降高度穩定性，能滿足大噸位貨物平穩舉升，運行平穩，無噪音，維修方便，使用壽命較長，升降貨梯的起升高度從1米18米不等。并可根據用戶要求定做特殊規格的升降貨梯，停電時可手動下降。緊急停止按鈕有效防止突發事故，方便，快捷，實用，地坑深度一般為15-30cm，高度不受限制，也可根據現場實際情況定做使用。層門可貫通，廠房?jī)?nèi)外可互相戳開，方便節省空間。特別適合2-3層鋼結構廠房，內外部均可使用，采用鞍山力盛合資泵站，無噪音耗電少，性能穩定可靠。

The guide rail type cargo elevator is a non scissor lift, which is made of high-strength manganese steel rectangular tube as a whole, and is equipped with steel wire rope to adjust the balance. Operation buttons can be set on each floor and the lifting table to realize multi-point control, and the interactive interlocking of upper and lower floors can achieve safe use. The hydraulic jacking system adopts the design of side mounted oil cylinders (oil cylinders on both sides), and the lifting height is stable, which can meet the requirements of stable lifting of large tonnage goods, stable operation, no noise, convenient maintenance, long service life, and the lifting height of the cargo elevator ranges from 1 m to 18 M. And according to the user's requirements, special specifications of the lift truck can be customized, and it can be lowered manually in case of power failure. The emergency stop button can effectively prevent sudden accidents, which is convenient, fast and practical. The depth of the pit is generally 15-30cm, and the height of the top floor is unlimited. It can also be customized according to the actual situation on site. The landing door can be connected, and the inside and outside of the plant can be poked open to each other, which is convenient to save space. It is especially suitable for 2-3 storey steel structure plants, both inside and outside. Anshan Lisheng joint venture pump station is adopted, which has no noise, less power consumption and stable and reliable performance.

二、適用范圍

2、 Scope of application

導軌式升降貨梯主要應用于化工，高溫，高壓，電廠，核工業基地等防爆企業。也可用于4S維修店升降汽車等行業。其優點是升降平穩，不用開挖地坑，因其構造較為復雜，在日常使用時系數更高但維修保養時也要求更高，但并不是過程復雜，而是保養步驟比較頻繁。

Guide rail type cargo elevators are mainly used in explosion-proof enterprises such as chemical industry, high temperature, high pressure, power plants, nuclear industrial bases, etc. It can also be used in 4S repair shops, lift trucks and other industries. Its advantage is that it can rise and fall smoothly without digging a pit. Because its structure is more complex, it has a higher safety factor in daily use, but it also requires higher maintenance. However, it is not the process that is complex, but the maintenance steps are more frequent.

三、使用方法及注意事項

3、 Usage and precautions

（1）工作前，排除設備周圍和下方的障礙物。

(1) Remove obstacles around and under the equipment before work.

（2）導軌式升降貨梯升降時，下方不得站人。

(2) When the guide rail type goods elevator lifts, no one is allowed to stand below.    

（3）嚴禁超載工作更不允許。

(3) Overloading is strictly prohibited, let alone allowed.    

（4）升降過程中隨時觀察升降貨梯平臺是否同步，發現異常，及時停機，檢查并排除故障后方能投入使用。

(4) During the lifting process, observe whether the lifting cargo elevator platform is synchronized at any time. If any abnormality is found, stop the machine in time, and put it into use after checking and troubleshooting.     

（5）下降操作時，先將導軌式升降貨梯平臺上升一點，注意觀察頂升架與運行導軌間是否完全脫開，否則停止下降。

(5) When descending, first raise the guide rail type cargo elevator platform a little, and pay attention to observe whether the jacking frame is completely separated from the running guide rail, otherwise stop descending.    

（6）導軌式升降貨梯長期不用時，工作平臺應降到低位位置，切斷電源。

(6) When the guide rail type cargo elevator is not used for a long time, the working platform should be lowered to the low position and the power supply should be cut off.      

四、維護與保養

4、 Maintenance and service

（1）導軌式升降貨梯操作人員須經培訓方可上崗位操作

(1) The operators of the guide rail type goods elevator must be professionally trained before they can operate on the post

（2）保險齒條及上下滑塊等移動部位，每月加一次潤滑脂。

(2) Grease the moving parts such as the safety rack and the upper and lower sliders once a month.     

（3）本機所有轉動部位，每周用機油壺加機油一次。

(3) Add oil to all rotating parts of the machine once a week with an oil kettle.    

（4）每年定期更換一次液壓油，油位應長期保持上限。

(4) Replace the hydraulic oil regularly every year, and the oil level should be kept at the upper limit for a long time. 

（5）非維修人員嚴禁私自維修和改裝電路以防觸電發生危險。

(5) Non professional maintenance personnel are strictly forbidden to repair and modify the circuit without permission to prevent electric shock.

以上就是為大家介紹的有導軌式升降平臺的詳細的介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://m.shyulang.cn

The above is a detailed introduction of the guide rail type lifting platform for you. I hope it can help you. If you have any questions, please contact us. We will provide services for you with a professional attitude http://m.shyulang.cn